|
威格士柱塞泵常見故障處理
1.柱塞泵輸出流量不足或不輸出油液
(1)吸入量不足。原因是吸油管路上的阻力過大或補油量不足。如泵的轉速過大，油箱中液面過低，進油管漏氣，濾油器堵塞等。
(2)泄漏量過大。原因是泵的間隙過大，密封不良造成。如配油盤被金屬碎片、鐵屑等劃傷，端面漏油;變量機構中的單向閥密封面配合不好，泵體和配油盤的支承面有砂眼或研痕等。可以通過檢查泵體內液壓油中混雜的異物判別泵被損壞的部位。
(3)傾斜盤傾角太小，泵的排量少，這需要調節變量活塞，增加斜盤傾角。
2.中位時排油量不為零 變量式軸向柱塞泵的斜盤傾角為零時稱為中位，此時泵的輸出流量應為零。但有時會出現中位偏離調整機構中點的現象，在中點時仍有流量輸出。其原因是控制器的位置偏離、松動或損傷，需要重新調零、緊固或更換。泵的角度維持力不夠、傾斜角耳軸磨損也會產生這種現象。
3.輸出流量波動 輸出流量波動與很多因素有關。對變量泵可以認為是變量機構的控制不佳造成，如異物進入變量機構，在控制活塞上劃出階痕、磨痕、傷痕等，造成控制活塞運動不穩定。由于放大器能量不足或零件損壞、含有彈簧的控制活塞的阻尼器效能差，都會造成控制活塞運動不穩定。流量不穩定又往往伴隨著壓力波動。這類故障一般要拆開液壓泵，更換受損零部件，加大阻尼，提高彈簧剛度和控制壓力等。
4.輸出壓力異常 泵的輸出壓力是由負載決定的，與輸入轉矩近似成正比。輸出壓力異常有兩種故障。
(1)輸出壓力過低 當泵在自吸狀態下，若進油管路漏氣或系統中液壓缸、單向閥、換向閥等有較大的泄漏，均會使壓力升不上去。這需要找出漏氣處，緊固、更換密封件，即可提高壓力。溢流閥有故障或調整壓力低，系統壓力也上不去，應重新調整壓力或檢修溢流閥。如果液壓泵的缸體與配流盤產生偏差造成大量泄漏，嚴重時，缸體可能破裂，則應重新研磨配合面或更換液壓泵。
(2)輸出壓力過高 若回路負載持續上升，泵的壓力也持續上升，當屬正常。若負載一定，泵的壓力超過負載所需壓力值，則應檢查泵以外的液壓元件，如方向閥、壓力閥、傳動裝置和回油管道。若最大壓力過高，應調整溢流閥。
5.振動和噪聲 振動和噪聲是同時出現的。它們不僅對機器的操作者造成危害，也對環境造成污染。
(1)機械振動和噪聲 如泵軸和電機軸不同心或頂死，旋轉軸的軸承、聯軸節損傷，彈性墊破損和裝配螺栓松動均會產生噪聲。對于高速運轉或傳輸大能量的泵，要定期檢查，記錄各部件的振幅、頻率和噪聲。如泵的轉動頻率與壓力閥的固有頻率相同時，將會引起共振，可改變泵的轉速以消除共振。
(2)管道內液流產生的噪聲 進油管道太細、進油濾油器通流能力過小或堵塞、進油管吸入空氣、油液豁度過高、油面過低吸油不足和高壓管道中產生液擊等，均會產生噪聲。因此，必須正確設計油箱，正確選擇濾油器、油管和方向閥。
6.威格士柱塞泵過熱 液壓泵過度發熱有兩個原因，一是機械摩擦生熱。由于運動表面處于干摩擦或半干摩擦狀態，運動部件相互摩擦生熱。二是液體摩擦生熱。高壓油通過各種縫隙泄漏到低壓腔，大量的液壓能損失轉為熱能。所以正確選擇運動部件之間的間隙、油箱容積和冷卻器，可以杜絕泵的過度發熱和油溫過高的現象。另外，回油過濾器堵塞造成回油背壓過高，也會引起油溫過高和泵體過熱。
7.漏油 柱塞泵漏油主要有以下原因:(1)主軸油封損壞或軸有缺陷、劃痕;(2)內部泄漏過大，造成油封處壓力增大，而將油封損傷或沖出;(3)泄油管過細過長，使密封處漏油;(4)泵的外接油管松動，管接頭損傷，密封墊老化或產生裂紋;(5)變量調節機構螺栓松動，密封破損;(6)鑄鐵泵殼有砂眼或焊接不良。
PVB10-RSY-31-CG-11
PVB10-RSY-31-CC-11-JA
PVB10-RSY-31-CC-11
PVB10-RSY-31-C-12
PVB15-LS-31-CC-11-JA
PVB10-RSY-31-C-11-JA
PVB10-RSY-31-C-11
PVB10-RSY-30-CC-JA
PVB10-RSY-30-CC-20-JA
PVB10-RSY-21-C-20-JA
PVB10-RSY-20-CG-20-JA
PVB10-RSY-20-CG-11
PVB10-RSY-20-CC-11
PVB10-RSY-20-C-11
PVB10-RSXY-41-CM-12
PVB10-RS-31-C-11-JA
PVB10-RSXY-41-C-12
PVB10-RS-31-C-11
PVB10-RSWY-41-CM-12
PVB10-RS-30-CC-12-JA
PVB10-RSWY-31-CC-11
PVB10-RSWY-31-C-11
PVB10-RSW-31-CC-11
PVB10-RSW-31-C-11
PVB10-RSW-21-CM-11
PVB10-RSY-41-C-10-JA
PVB10-RS-41-CM-11-JA
PVB10-RS-41-C-12-S124
PVB10-RDY-31-M-10
PVB10-RS-31-CM-11-JA
PVB10-RSY-31-CC-11-JA
PVB10-RS-31-C-11-JA
PVB10-RS-30-CC-12-JA
PVB10-RDXY-31-M-10
PVB10-RDX-31-M-11-HJ
PVB10-RD-32-M-11
PVB10-RSY-21-C-20-JA
PVB10-RD-31-M-11
PVB10-LSY-41-CVP-13
PVB10-LSY-41-CM-12
PVB10-LSY-41-C-12
PVB10-LSY-31-C-11
PVB10-LSY-21-C-11
PVB10-LSY-20-C-11
PVB10-LS-31-CC-11
PVB10-LS-31-C-11
PVB10-LDY-31-M-10
PVB10-LDY-31-H-10
PVB10-LD-32-M-11
PVB10-FRSY-41-C-12
PVB10-FRSY-31-CC-11
PVB10-FRS-31-CC-11
PFB5-UY-20
PFB5-RSY-10
PVB10-LS-31-C-11
PFB5-R-20
M-PVB45-LSF-20-C
M-PVB45-LSF-10-C-11
PVB10-FRS-31-CC-11
M-PVB45-LSF-10-C-10
PFB5-UY-20
M-PVB29-RS-20-CG-10
PVH131R03AF30E252008001AD1AA010A
PVH131C-RAF-3S-11-C25VT8-31
PVH098R13AJ70B252000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25V-31
PVH098R51AD30A070000002001AF010A
PVH98QPC2-RSM-1S-11-CM7-31
PVH098R02AJ30D250004001002AE010A
PVH98QIC-RF-2D-11-C25T4-31
PVH074R01AB10A070000002001AE010A
PVH74QIC-RSM-1S-11-CM7-31
PVH098R13AJ70A250000001AD1AE010A
PVH98QIC3-RAF-13S-11-C25-31
PVH098R03AJ30A250000001AD2AA010A
PVH98C-RAF-3D-11-C25-31
PVH074L02AB10B252000001001AA010A
PVH74C-LM-2S-11-C25V-31
PVH074L02AB10B252000001AF1AA010A
PVH74C-LAM-2S-11-C25V-31-036
PVH074R0NAB10A070000001001AF010A
PVH74QPM-RM-NS-11-CM7-31
PVH074R51AB10A070000002001AE010A
PVH74QIC2-RSM-1S-11-CM7-31
PVH057L52AA10B252000001001AA010A
PVH57C2-LF-2S-11-C25V-31
PVH131L02AF30B252000001002AA010A
PVH131C-LF-2D-11-C25V-31
PVH074R13AA10E252007001AF1AE010A
PVH74QIC-RAF-13S-11-C25VT7-31
PVH057R02AA10E252007001001AE010A
PVH57QIC-RF-2S-11-C25VT7-31
PVH074R01AA10B252000001001AN010A
PVH74C-RF-1S-11-C25V-31-115
PVH098R01AJ30A250000001001AN010A
PVH98C-RF-1S-11-C25-31-115
PVH057R02AA10A150000001AE2AA010A
PVH57C-RAF-2D-11-C15-31
PVH098R01AJ30D250005001001BC010A
PVH98QIC-RF-1S-11-C25T5-31-115
PVH098L02AJ30B102000AG1001AA010A
PVH98C-LF-2S-11-C10V-31
PVH074R02AA10A190000001AP2AA010A
PVH74C-RCF-2D-11-C19-31-036
PVH074R02AA10A190000001002AA010A
PVH74C-RF-2D-11-C19-31
PVH098L02AJ30A100000AG1001AA010A
PVH98C-LF-2S-11-C10-31
PVH074L02AA10A190000001002AA010A
PVH74C-LF-2D-11-C19-31
PVH098R02AJ30A250000001002AA010A
PVH98C-RF-2D-11-C25-31
PVH074R01AA10A070000001002AE010A
PVH74QIC-RF-1D-11-CM7-31
PVH098R01AJ30A070000001001AN010A
PVH98C-RF-1S-11-CM7-31-115
PVH098R13AJ30D070004001AD1AF010A
PVH98QPC-RAF-13S-11-CM7T4-31
PVH098R03AJ30B252000AL1AD1BH010A
PVH98QIC-RAF-3S-10-C25V-31-208
PVH057L02AA10B122000AG1AY1AA010A
PVH57C-LBF-2S-11-C12V-31-114
PVH074R60AB10B432100001AF2AA010A
PVH74C2-RAM-10D-11-C241V21-31
PVH057R01AA10J002004AW1001AE010A
PVH57QIC-RF-1S-11-ICT4-31
PVH074R01AA10J002004AW1001AE010A
PVH74QIC-RF-1S-11-ICT4-31
PVH131R13AF30J002004BD1001AE010A
PVH131QIC-RF-13S-11-ICT4-31
PVH098R01AJ30B072000002001AE010A
PVH98QIC-RSF-1S-11-CM7V-31
PVH098R01AJ30D250004001001AA010A
PVH98C-RF-1S-11-C25T4-31
PVH074L02AA10B102000AG1AF2AA010A
PVH74C-LAF-2D-11-C10V-31-036
PVH074R03AA10B172000001AF1AA010A
PVH74C-RAF-3S-11-C17V-31
PVH098L02AJ30A130000AG1001AA010A
PVH98C-LF-2S-11-C13-31
PVH098R13AJ30E252010001AD1AE010A
PVH98QIC-RAF-13S-11-C25VT10-31
PVH098R13AJ30E252015001AD1AE010A
PVH98QIC-RAF-13S-11-C25VT15-31
PVH098R13AJ30A070000001AD1AF010A
PVH98QPC-RAF-13S-11-CM7-31
PVH131L13AF30E132004AG1001AE010A
PVH131QIC-LF-13S-11-C13VT4-31
PVH098R13AJ30E252018001AD1AE010A
PVH98QIC-RAF-13S-11-C25VT18-31
PVH074R02AA10E252015001001AE010A
PVH74QIC-RF-2S-11-C25VT15-31
PVH074R01AA10D210007001001AE010A
PVH74QIC-RF-1S-11-C21T7-31
PVH074R01AA10E252009001001AE010A
PVH74QIC RF 1S 11 C25VT9 31
PVH074R13AA10E252015001AF1AE010A
PVH74QIC-RAF-13S-11-C25VT15-31
PVH131R16AF30D250015001AD1AA010A
PVH131C-RAF-16S-11-C25T15-31
PVH098R02AJ30C200004001002AA010A
PVH98C-RF-2D-11-C25T4S-31
PVH131R16AF30C250004001AD1AA010A
PVH131C-RAF-16S-11-C25T4S-31
PVH074R01AA10B252000001001BC010A
PVH74QIC-RF-1S-11-C25V-31-115
PVH057R01AA10E252004001AE1AA010A
PVH57C-RAF-1S-11-C25VT4-31
PVH098R01AJ30D250010001001AE010A
